CTBD Diesel Injectors
Compatible with Porsche Cayenne (958), Volkswagen Touareg (7P)
- OEM Tested & Calibrated
- 12-Month Warranty
- Free UK Delivery
Select the correct injector for your CTBD engine below
Fits Porsche Cayenne (958), Volkswagen Touareg (7P) and more
Top injectors for CTBD
Compatible Injectors for CTBD
- OEM Tested
- 12-Month Warranty
- Free UK Delivery
Common problems solved by these injectors
About the CTBD engine
The CTBD is a 3.0l v6 tdi cr common rail diesel engine. This engine uses Bosch diesel injectors.
How Diesel Injectors Are Remanufactured
Watch our 3D walkthrough of the diesel injector remanufacturing process and see how injectors are professionally restored for reliable service.
Vehicles Using CTBD Engine
| Vehicle | Engine | Years |
|---|---|---|
| Porsche Cayenne (958) injector | 3.0 Diesel | 2011–2018 |
| Volkswagen Touareg (7P) injector | 3.0 V6 TDI | 2011–2018 |
Common CTBD Injector Problems
Rough idle and engine vibration
Worn injector nozzles cause uneven fuel spray, leading to rough idle at low RPM. Most noticeable when the engine is cold.
Excessive exhaust smoke
Black or blue-grey smoke on acceleration indicates poor fuel atomisation. This is often caused by carbon buildup on the injector nozzle tip.
Poor fuel economy
A worn or leaking injector delivers incorrect fuel quantities, reducing efficiency by 10–20% in severe cases.
Engine misfire under load
Intermittent misfires during acceleration suggest one or more injectors are failing to deliver the correct fuel pressure.
Difficult cold starting
Degraded injector nozzles struggle to atomise fuel at lower cranking pressures, causing extended crank times in cold weather.
Loss of power
Gradual power loss across the rev range, particularly above 2500 RPM, can indicate injector flow rate degradation.
Increased diesel knock
Louder than normal combustion noise, especially at idle, can indicate incorrect injection timing due to worn injector internals.
CTBD Technical Specifications
Displacement
—
Power
—
Torque
—
Fuel System
Common Rail Direct Injection
The CTBD is a 3.0l v6 tdi cr common rail diesel engine. This engine uses Bosch diesel injectors.
Engine Intelligence
Audi / VW / Porsche 3.0 V6 TDI (A6/A7 C7, Touareg 7P, Macan, Cayenne — CR piezo)
Documented failure modes
- Piezo injector electrical faults logging group supply-voltage codes
- Injector correction values drifting out of range as the piezo stack ages
- Injector sealing washer leaks allowing combustion blow-by around the injector
Diagnostic guidance
- Compare injector balance / correction values across all six cylinders — an outlier identifies the failing unit
- On group supply-voltage codes, check the injector harness and connectors before replacing hardware
- Check return flow to identify a hydraulically defective injector
- Injector coding is required after fitting — follow the manufacturer procedure
Fitment note: VAG 3.0 V6 TDI injection changed across generations — this CKV/CTB/CVV-era engine takes the 0445117027-type unit, different from earlier CJG-era references; always match the number etched on the injector body.
Related CTBD Engine Guides
Related Pages
Bosch 3.0L V6 TDI CR — browse compatible engines, vehicles, and injectors