D5244T Diesel Injectors
Compatible with Volvo S60, Volvo S80, Volvo V70, and 2 more
- OEM Tested & Calibrated
- 12-Month Warranty
- Free UK Delivery
Select the correct injector for your D5244T engine below
Fits Volvo S60, Volvo S80, Volvo V70, Volvo XC70 and more
Top injectors for D5244T
Compatible Injectors for D5244T
- OEM Tested
- 12-Month Warranty
- Free UK Delivery
Common problems solved by these injectors
About the D5244T engine
The D5244T is a 2.4l d5 common rail diesel engine. This engine uses Bosch diesel injectors.
How Diesel Injectors Are Remanufactured
Watch our 3D walkthrough of the diesel injector remanufacturing process and see how injectors are professionally restored for reliable service.
Vehicles Using D5244T Engine
| Vehicle | Engine | Years |
|---|---|---|
| Volvo S60 injector | 2.4 D5 | 2001–2010 |
| Volvo S80 injector | 2.4 D5 | 2001–2006 |
| Volvo V70 injector | 2.4 D5 | 2001–2007 |
| Volvo XC70 injector | 2.4 D5 | 2002–2007 |
| Volvo XC90 injector | 2.4 D5 | 2002–2010 |
Common D5244T Injector Problems
Rough idle and engine vibration
Worn injector nozzles cause uneven fuel spray, leading to rough idle at low RPM. Most noticeable when the engine is cold.
Excessive exhaust smoke
Black or blue-grey smoke on acceleration indicates poor fuel atomisation. This is often caused by carbon buildup on the injector nozzle tip.
Poor fuel economy
A worn or leaking injector delivers incorrect fuel quantities, reducing efficiency by 10–20% in severe cases.
Engine misfire under load
Intermittent misfires during acceleration suggest one or more injectors are failing to deliver the correct fuel pressure.
Difficult cold starting
Degraded injector nozzles struggle to atomise fuel at lower cranking pressures, causing extended crank times in cold weather.
Loss of power
Gradual power loss across the rev range, particularly above 2500 RPM, can indicate injector flow rate degradation.
Increased diesel knock
Louder than normal combustion noise, especially at idle, can indicate incorrect injection timing due to worn injector internals.
D5244T Technical Specifications
Displacement
—
Power
—
Torque
—
Fuel System
Common Rail Direct Injection
The D5244T is a 2.4l d5 common rail diesel engine. This engine uses Bosch diesel injectors.
Engine Intelligence
Volvo 2.4 D5 (D5244T — S60, V70, XC70, XC90)
Documented failure modes
- Injector back-leak beyond specification on high-mileage engines
- Nozzle wear causing over-fuelling on individual cylinders
- Injector seat sealing failure causing compression leakage (black tar around injector)
Diagnostic guidance
- Five-cylinder layout — compare leak-off volumes across all five injectors, not just the suspect one
- Clean around the injector seats before removal to stop debris entering the bores
- Check for carbonised sealing washers ('black death') and clean seats fully before refitting
Fitment note: Early and later D5244T variants use different Bosch references — match the 0445110 number etched on the injector body before ordering.
Related D5244T Engine Guides
Related Pages
Bosch 2.4L D5 — browse compatible engines, vehicles, and injectors